Product ID:AAFES SPRAY ENAMEL,10012 ALUMINUM
MSDS Date:04/27/1993
FSC:8010
NIIN:00F051921
MSDS Number: CCFZD

UNITED COATINGS INC

2850 FESTIVAL DRIVE
KANKAKEE, IL 60901-5000
US

Emergency Phone: 800-621-1000

Info Phone: 800-782-7889

Cage: UNITD

UNITED COATINGS INC

KANKAKEE, IL 60901 US

Telephone: 815-935-1200

Cage: UNITD

TOLUENE (IARC CARC- GROUP 3) *96-3*

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ALUMINUM *96-3*

CAS: 7429-90-5

RTECS: BD0330000

Fraction By Weight: <5%

OSHA PEL 15 MG/CUM

ACGIH TLV: 10 MG/CUM (DUST)

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: <5%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

PROPANE (DIMETHYLMETHANE) *96-3*

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 15%

OSHA PEL 1000 PPM

ACGIH TLV: SIMPLE ASPHYXIANT

BUTANE, N-BUTANE *96-3*

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 15%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES/SKIN: LIQUID CAN CAUSE FROSTBITE
& BURNS. INHALATION: ASPHYXIANT, MAY EXHIBIT ANESTHETIC PROPERTIES
& DEATH.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, DISORIENTATION, LACK OF COORDINATION,
RAPID RESPIRATION, HEADACHE, NAUSEA, UNCONSCIOUSNESS, COMA.

First Aid:EYES: FLUSH W/FRESH WATER FOR 15 MINS. REMOVE CONTACT LENSES
IF WORN. SKIN: FLUSH/IMMERSE AREAS IN LUKEWARM WATER. KEEP WARM &
ACCUMULATE CIRCULATION W/MASSAGE. INHALATION: REMOVE TO FRESH AIR.
GIVE C PR/OXYGEN IF NEEDED. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point:40F
Lower Limits:1.8
Upper Limits:9.5
Extinguishing Media:WATER SPRAY, DRY POWDER/CO2.
Fire Fighting Procedures:DON'T ENTER ANY ENCLOSED/CONFINED FIRE SPACE
W/O PROPER PROTECTIVE EQUIPMENT & SCBA. USE WATER TO COOL FIRE
EXPOSED TANKS, SURROUNDINGS & TO PROTECT PERSONNEL.
Unusual Fire/Explosion Hazard:EXTREME FIRE HAZARD. LIQUID QUICKLY
EVAPORATES AT LOW TEMPS & FORMS VAPORS WHICH CAN CATCH FIRE/BURN
W/EXPLOSIVE VIOLENCE. (SEE SUPP)

Spill Release Procedures:ISOLATE HAZARD AREA & DENY ENTRY. PUT ON FULL
PROTECTIVE CLOTHING & SCBA BEFORE REENTERING AREA. TURN OFF GAS LOW
& REMOVE/ELIMINATE SOURCES OF IGNITION. IF NOT IGNITED, DISPERSE
W/WATER SPRAY/BY FLOO DING. ISOLATE FOR 1/2 MILE IN ALL DIRECTIONS.

Handling and Storage Precautions:STORE & USE CYLINDERS/TANKS IN WELL
VENTILATED AREAS, AWAY FROM HEAT, DIRECT SUNLIGHT & SOURCES OF
IGNITION. NO SMOKING IN AREAS OF STORAGE/USE.
Other Precautions:ELECTRICALLY BOND & GROUND ALL LINES & EQUIPMENT.
FOLLOW STANDARD PROCEDURE FOR HANDLING CYLINDERS & TANKS OF
FLAMMABLE, COMPRESSED GAS. PROVIDE PROTECTION AGAINST DAMAGING
CYLINDERS & TANKS. AVOID CO NTACT W/SKIN/EYES. (SEE SUPP)

Respiratory Protection:DEPENDING ON THE AIRBORNE CONCENTRATION, USE A
RESPIRATOR/GAS MASK W/APPROPRIATE CARTRIDGES & CANISTERS (NIOSH
APPROVED, IF AVAILABLE)/SUPPLIED AIR EQUIPMENT. SELF CONTAINED
RESPIRATORS SHOULD BE AVAI LABLE FOR NON-ROUTINE & EMERGENCYS.
Ventilation:LOCAL EXHAUST: MAY BE REQUIRED. MECHANICAL (GENERAL): FOR
MAINTAINING AIRBORNE CONCENTRATIONS < EXPOSURE LIMITS.
Protective Gloves:THERMAL
Eye Protection:GOGGLES/SAFETY GLASSES
Supplemental Safety and Health
FIRE HZRD CONT'D: INVISIBLE VAPOR SPREADS EASILY & CAN BE SET ON FIRE
BY MANY IGNITION SOURCES. PETROLEUM GASES ARE HEAVIER THAN AIR &
TRAVEL LONG THE GROUND/INTO DRAINS TO DISTANT IGNITION SOURCES &
FLASH BACK. PREC CONT'D: DON'T COMPLETELY EXTINGUISH FLAME UNLESS
GAS FLOW IS SHUT OFF.

Boiling Pt:B.P. Text:43.70F
Vapor Pres:70
Vapor Density:1.5
Spec Gravity:0.5409
Solubility in Water:<0.1%
Appearance and Odor:LIQUID, ESSENTIALLY ODORLESS

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, CHLORINE, PERMANGANATES, DICHROMATES.
Stability Condition to Avoid:SPARKS, OPEN FLAME/ANY SOURCE OF IGNITION,
DIRECT SUNLIGHT.
Hazardous Decomposition Products:NORMAL COMBUSTION: CO
Conditions to Avoid Polymerization:KEEP SEPARATE FROM OXIDIZING AGENTS.

Waste Disposal Methods:DISPOSE OF PRODUCT IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.